DTC list故障码(DTC)列表
|
No.序号 |
DTC故障码 |
Fault code description故障码描述 |
Possible reasons可能原因 |
Solution解决办法 |
|---|---|---|---|---|
|
1 |
P16E091
|
Precharge process timed out预充过程超时
|
1. High voltage power on is not completed1.高压上电未完成
|
|
|
2. External load works in advance2.外部负载提前工作
|
||||
|
2 |
P16E291
|
The high-voltage power-off process times out when waiting for the current to drop.高压下电过程等待电流下降超时
|
1. The external load did not stop working in time during the high-voltage power-off process.1.高压下电过程中外部负载没有及时停止工作
|
|
|
3 |
P16E391
|
High voltage power off process times out高压下电过程超时
|
1. The process of disconnecting the main relay times out1.断开主继电器过程超时
|
|
|
4 |
P16E491
|
Emergency high voltage power-off process times out紧急高压下电过程超时
|
1. The process of disconnecting the main relay times out1.断开主继电器过程超时
|
|
|
5
|
P164219
|
Current exceeds limit during precharge process预充过程电流超限
|
1. External load works in advance1.外部负载提前工作
|
|
|
2. Main positive main negative external load circuit short circuit2.主正主负外部负载回路短路
|
||||
|
6 |
P16E219
|
The current exceeds the limit during high-voltage power-on.高压上电过程电流超限
|
1. The current during closing of the main positive relay exceeds the limit.1.闭合主正继电器过程电流超限
|
|
|
7 |
P16A872
|
Main negative relay cannot close主负继电器无法闭合
|
1. Main negative relay failure1.主负继电器故障
|
|
|
8 |
P16A373
|
The main and negative relays are stuck主负继电器粘连
|
1. Main negative relay failure1.主负继电器故障
|
|
|
9 |
P16A072
|
Main positive relay cannot close主正继电器无法闭合
|
1. Main positive relay failure1.主正继电器故障
|
|
|
10 |
P16A173
|
Main positive relay stuck主正继电器粘连
|
1. Main positive or precharge relay failure1.主正或者预充继电器故障
|
|
|
11 |
P16A472
|
Precharge relay cannot close预充继电器无法闭合
|
1. Precharge relay failure1.预充继电器故障
|
|
|
12 |
P16A273
|
Precharge relay sticking预充继电器粘连
|
1. Main positive or precharge relay failure1.主正或者预充继电器故障
|
|
|
13 |
P16E319
|
Extreme charging overcurrent fault极限充电过流故障
|
1. Current exceeds limit in service mode1.服务模式下电流超限
|
|
|
14 |
P163011
|
Main positive relay low side short to ground主正继电器低边短地
|
1. The low-side drive line of the main positive relay is short-circuited to ground.1.主正继电器低边驱动线短路到地
|
|
|
15 |
P163111
|
Main negative relay low side short to ground主负继电器低边短地
|
1. The low-side drive line of the main negative relay is short-circuited to ground.1.主负继电器低边驱动线短路到地
|
|
|
16 |
P163211
|
Precharge relay low side short to ground预充继电器低边短地
|
1. The low-side drive line of the precharge relay is short-circuited to ground.1.预充继电器低边驱动线短路到地
|
|
|
17 |
P163311
|
Main positive relay high side short to ground主正继电器高边短地
|
1. The high-side drive line of the main positive relay is short-circuited to ground.1.主正继电器高边驱动线短路到地
|
|
|
18 |
P163411
|
Main negative relay high side short to ground主负继电器高边短地
|
1. The high-side drive line of the main negative relay is short-circuited to ground.1.主负继电器高边驱动线短路到地
|
|
|
19 |
P163511
|
Precharge relay high side short to ground预充继电器高边短地
|
1. The high-side drive line of the precharge relay is short-circuited to ground.1.预充继电器高边驱动线短路到地
|
|
|
20 |
P163312
|
Main positive relay high side short power supply主正继电器高边短电源
|
1. The high-side drive line of the main positive relay is short-circuited to the power supply.1.主正继电器高边驱动线短路到电源
|
|
|
21 |
P163012
|
Main positive relay low side short power supply主正继电器低边短电源
|
1. The low-side drive line of the main positive relay is short-circuited to the power supply.1.主正继电器低边驱动线短路到电源
|
|
|
22 |
P163112
|
Main negative relay low side short power supply主负继电器低边短电源
|
1. The low-side drive line of the main negative relay is short-circuited to the power supply.1.主负继电器低边驱动线短路到电源
|
|
|
23 |
P163412
|
Main negative relay high side short power supply主负继电器高边短电源
|
1. The high-side drive line of the main negative relay is short-circuited to the power supply.1.主负继电器高边驱动线短路到电源
|
|
|
24 |
P163512
|
Precharge relay high side short power supply预充继电器高边短电源
|
1. The high-side drive line of the precharge relay is short-circuited to the power supply.1.预充继电器高边驱动线短路到电源
|
|
|
25 |
P163212
|
Precharge Relay Low Side Short Supply预充继电器低边短电源
|
1. The low-side drive line of the precharge relay is short-circuited to the power supply.1.预充继电器低边驱动线短路到电源
|
|
|
26 |
P163712
|
DC fast charging relay high side short power supply快充电继电器高边短电源
|
1. The high-side drive line of the DC fast charging relay is short-circuited to the power supply.1.快充继电器高边驱动线短路到电源
|
|
|
27 |
P163711
|
DC fast charging relay high side short to ground快充电继电器高边短地
|
1. The high-side drive line of the DC fast charging relay is short-circuited to ground.1.快充继电器高边驱动线短路到地
|
|
|
28
|
P163612
|
DC fast charging relay low side short power supply快充电继电器低边短电源
|
1. The low-side drive line of the DC fast charging relay is short-circuited to the power supply.1.快充继电器低边驱动线短路到电源
|
|
|
29 |
P163611
|
DC fast charging relay low side short to ground快充电继电器低边短地
|
1. The low-side drive line of the DC fast charging relay is short-circuited to ground.1.快充继电器低边驱动线短路到地
|
|
|
30 |
P16904B
|
Precharge resistor overheat alarm预充电阻过热告警
|
1. Repeated power on and off causes the precharge resistor to overheat.1.反复上下电导致预充电阻过热
|
|
|
31 |
P164027
|
The voltage rises too fast during pre-charging预充过程电压上升过快
|
1. The external load voltage rises too fast during the precharge process.1.预充过程外部负载电压上升速度过快
|
|
|
32 |
P164026
|
The voltage rises too slowly during pre-charging预充过程电压上升过慢
|
1. The external load voltage rises too slowly during the precharge process.1.预充过程外部负载电压上升速度过慢
|
|
|
33 |
P164092
|
The energy consumed during the precharging process exceeds the limit.预充过程消耗能量超限
|
1. External load works in advance1.外部负载提前工作
|
|
|
2. Main positive main negative external load circuit short circuit2.主正主负外部负载回路短路
|
||||
|
34 |
P16E118
|
Severe overcurrent during charging充电严重过流
|
1. The charging current exceeds the allowable value of the battery1.充电电流超出电池允许值
|
|
|
35
|
P16E119
|
Discharge serious overcurrent放电严重过流
|
1. The discharge current exceeds the allowable value of the battery1.放电电流超出电池允许值
|
|
|
36 |
P164019
|
Charging overcurrent alarm充电过流告警
|
1. The charging current exceeds the allowable value of the battery1.充电电流超出电池允许值
|
|
|
37
|
P16E419
|
Discharge overcurrent alarm放电过流告警
|
1. The discharge current exceeds the allowable value of the battery1.放电电流超出电池允许值
|
|
|
38
|
P161302
|
Current sensor signal exceeds limit电流传感器信号超限
|
1. The bus current exceeds the range of the current sensor.1.母线电流超出电流传感器量程
|
|
|
39 |
P16E217
|
Severe overvoltage of the monomer单体严重过压
|
1. Battery overcharge1.电池过充
|
|
|
40
|
P16E216
|
The unit is seriously under-voltage单体严重欠压
|
1. Battery is over-discharged1.电池过度放电
|
|
|
2. Store for a long time without charging in time2.未及时充电后长时间存放
|
||||
|
41 |
P16E117
|
Cell overvoltage alarm单体过压告警
|
1. Battery overcharge1.电池过充
|
|
|
42
|
P16E116
|
Cell undervoltage alarm单体欠压告警
|
1. Battery is over-discharged1.电池过度放电
|
|
|
2. Store for a long time without charging in time2.未及时充电后长时间存放
|
||||
|
43
|
P16E517
|
The total voltage of the battery pack is seriously overvoltage电池包总电压严重过压
|
1. Battery overcharge1.电池过充
|
|
|
44 |
P16E516
|
The total voltage of the battery pack is seriously undervoltage电池包总电压严重欠压
|
1. Battery is over-discharged1.电池过度放电
|
|
|
2. Store for a long time without charging in time2.未及时充电后长时间存放
|
||||
|
45
|
P16E417
|
Battery pack total voltage overvoltage alarm电池包总电压过压告警
|
1. Battery overcharge1.电池过充
|
|
|
46 |
P16E416
|
Battery pack total voltage undervoltage alarm电池包总电压欠压告警
|
1. Battery is over-discharged1.电池过度放电
|
|
|
2. Store for a long time without charging in time2.未及时充电后长时间存放
|
||||
|
47
|
P164364
|
Total battery voltage detection error (U1)电池总电压检测错误(U1)
|
1. Abnormal high-voltage sampling1.高压采样异常
|
|
|
48
|
P16A064
|
Main positive relay outer voltage detection error (U2)主正继电器外侧电压检测错误(U2)
|
1. Abnormal high-voltage sampling1.高压采样异常
|
|
|
49 |
P16A264
|
Main negative relay outer voltage detection error (U3)主负继电器外侧电压检测错误(U3)
|
1. Abnormal high-voltage sampling1.高压采样异常
|
|
|
50
|
P164464
|
Battery main fuse outer voltage detection error (U5)电池主保险外侧电压检测错误(U5)
|
1. Abnormal high-voltage sampling1.高压采样异常
|
|
|
51 |
P16A602
|
DC fast charge relay outer voltage detection error (U6)快充继电器外侧电压检测错误(U6)
|
1. Abnormal high-voltage sampling1.高压采样异常
|
|
|
52
|
P164164
|
Module voltage detection error模组电压检测错误
|
1. Abnormal module voltage sampling1.模组电压采样异常
|
|
|
53 |
P164264
|
Cell voltage detection error单体电压检测错误
|
1. There is a big difference between the cell voltage sampling and the real value.1.单体电压采样与真实值差异大
|
|
|
54 |
P161064
|
Current sensor 1 detection error电流传感器1检测错误
|
1. There is a big difference between the sampling value of current sensor 1 and the sampling value of current sensor 2.1.电流传感器1采样值与电流传感器2采样值差异大
|
|
|
55
|
P161164
|
Current sensor 2 detection error电流传感器2检测错误
|
1. There is a big difference between the sampling value of current sensor 1 and the sampling value of current sensor 2.1.电流传感器1采样值与电流传感器2采样值差异大
|
|
|
56
|
P161102
|
Current sensor 2 communication failure电流传感器2通讯故障
|
1.BMS internal communication failure1.BMS内部通讯故障
|
|
|
2. Current sensor 2 failure2.电流传感器2故障
|
||||
|
57 |
P16E301
|
The load voltage does not drop in time负载电压未及时下降
|
1. The external load voltage does not drop to a safe value when powering on.1.上电时外部负载电压未下降至安全值
|
|
|
58
|
P16E298
|
The battery temperature is seriously too high电池温度严重过高
|
1. The battery temperature exceeds the allowable range and the cooling system does not work properly.1.电池温度超出允许使用值范围，冷却系统未正常工作
|
|
|
59 |
P16E099
|
Battery temperature is seriously too low电池温度严重过低
|
1. The battery temperature exceeds the allowable range and the heating system does not work properly.1.电池温度超出允许使用值范围，加热系统未正常工作
|
|
|
2. Handle low temperature environment for a long time2.长时间处理低温环境
|
||||
|
60 |
P16E198
|
Battery temperature is too high alarm电池温度过高告警
|
1. The battery temperature exceeds the alarm value and the cooling system does not work properly.1.电池温度超出报警值，冷却系统未正常工作
|
|
|
61 |
P16E399
|
Battery temperature is too low alarm电池温度过低告警
|
1. The battery temperature exceeds the alarm value and the heating system does not work properly.1.电池温度超出报警值，加热系统未正常工作
|
|
|
2. Exposed to low temperature environment for a long time2.长时间处于低温环境
|
||||
|
62
|
P164391
|
Battery power is seriously too high电池电量严重过高
|
1. Battery overcharging1.电池过度充电
|
|
|
63 |
P164591
|
Battery power is seriously low电池电量严重过低
|
1. Battery is over-discharged1.电池过度放电
|
|
|
64
|
P164291
|
Battery power is too high alarm电池电量过高告警
|
1. Battery overcharging1.电池过度充电
|
|
|
65 |
P164491
|
Low battery warning电池电量过低告警
|
1. Battery is over-discharged1.电池过度放电
|
|
|
66 |
P164091
|
Insulation detection timeout绝缘检测超时
|
1. No insulation value detected after timeout1.超时未检测到绝缘值
|
|
|
67
|
P165713
|
high-voltage interlock (HVIL) disconnection fault高压互锁断开故障
|
1. Abnormal high-voltage interlock (HVIL) circuit1.高压互锁线路异常
|
|
|
68
|
P164113
|
High voltage main fuse disconnection fault高压主保险断开故障
|
1. High voltage main fuse is disconnected1.高压主保险断开
|
|
|
69 |
P168392
|
Low battery life warning电池寿命过低告警
|
1. The aging degree of the battery exceeds the predetermined value and reaches the service life limit.1.电池老化程度超出预定值，达到使用寿命限制
|
|
|
70
|
P168092
|
Battery life is too low电池寿命过低
|
1. The aging degree of the battery exceeds the predetermined value and reaches the service life limit.1.电池老化程度超出预定值，达到使用寿命限制
|
|
|
71
|
P168192
|
Battery life is severely low电池寿命严重过低
|
1. The aging degree of the battery exceeds the predetermined value and reaches the service life limit.1.电池老化程度超出预定值，达到使用寿命限制
|
|
|
72 |
P169002
|
Temperature sampling failure (derived from mask and valid)温度的采样故障（来源于mask和valid）
|
1. Module temperature sampling line failure1.模组温度采样线故障
|
|
|
2. Sampling chip failure2.采样芯片故障
|
||||
|
3. Abnormal temperature sensation3.温感异常
|
||||
|
73
|
P169909
|
Sampling failure of cell voltage (derived from mask and valid)单体电压的采样故障（来源于mask和valid）
|
1. Single voltage sampling line failure1.单体电压采样线故障
|
|
|
2. Sampling chip failure2.采样芯片故障
|
||||
|
74
|
P16E806
|
Large inconsistency in cell power单体电量不一致性大
|
1. The difference in power of the cells inside the battery is too large, and the cells are in an unbalanced state.1.电池内部电芯电量差异过大，电芯处于不均衡状态
|
|
|
75 |
P164200
|
External request for emergency high voltage power off外部请求紧急高压下电
|
1. The vehicle suffered a collision failure1.整车发生了碰撞故障
|
|
|
76
|
P16994B
|
Slave board temperature is too high从板温度过高
|
1. The temperature of the battery slave plate exceeds the allowable use value range1.电池从板温度超出允许使用值范围
|
|
|
77
|
P16A372
|
DC fast charging relay cannot close快充电继电器无法闭合
|
1. DC fast charging relay failure1.快充继电器故障
|
|
|
78 |
P16A473
|
DC fast charging relay sticking快充电继电器粘连
|
1. DC fast charging relay failure1.快充继电器故障
|
|
|
79 |
P16E21A
|
Insulation fault (relay closed)绝缘故障（继电器闭合）
|
1. Abnormal insulation of the high-voltage part of the vehicle1.整车高压部分绝缘异常
|
|
|
80 |
P16E31A
|
Insulation fault (relay open)绝缘故障（继电器断开）
|
1. Abnormal insulation of the high-voltage part of the vehicle1.整车高压部分绝缘异常
|
|
|
81 |
P166342
|
Non-volatile storage initialization failed非易失存储初始化失败
|
1. Non-volatile storage initialization failed1.非易失存储初始化失败
|
|
|
82 |
P16E401
|
Emergency power off and hard wire failure紧急下电硬线故障
|
1. Abnormal hard-wired output during emergency power-off1.紧急下电硬线输出异常
|
|
|
83 |
P16A101
|
Relay drive circuit failure继电器驱动回路故障
|
1. Relay drive circuit failure1.继电器驱动回路故障
|
|
|
84 |
P164102
|
High voltage sampling interface failure高压采样接口故障
|
1. High voltage sampling interface failure1.高压采样接口故障
|
|
|
85 |
P164201
|
Power port failure电源口故障
|
1. Power port failure1.电源口故障
|
|
|
86 |
P164301
|
high-voltage interlock (HVIL) interface failure高压互锁接口故障
|
1. high-voltage interlock (HVIL) interface failure1.高压互锁接口故障
|
|
|
87 |
P164401
|
Current sensor power supply port failure电流传感器供电口故障
|
1. Current sensor power supply port failure1.电流传感器供电口故障
|
|
|
88
|
P167105
|
Storage fails after powering off下电存储失败
|
1. Storage fails when powering off at low voltage1.低压下电时存储失败
|
|
|
89
|
P169191
|
Cell overcharge单体过充
|
1. Battery overcharge1.电池过充
|
|
|
90
|
P164296
|
Cell over discharge单体过放
|
1. Battery is over-discharged1.电池过度放电
|
|
|
2. Store for a long time without charging in time2.未及时充电后长时间存放
|
||||
|
91 |
P160217
|
12V power supply voltage is high12V供电电压高
|
1. The 12V battery voltage is too high1.铅酸蓄电池电压过高
|
|
|
92 |
P160016
|
12V power supply voltage is low12V供电电压低
|
1. 12V battery loses power1.铅酸蓄电池亏电
|
|
|
93
|
P164701
|
Balance loop failure均衡回路故障
|
1. Balance resistor failure1.均衡电阻故障
|
|
|
2. Balance circuit switch failure2.均衡回路开关故障
|
||||
|
94
|
P16A413
|
Precharge relay drive line open circuit fault预充继电器驱动线开路故障
|
1. The precharge relay drive line is open circuit1.预充继电器驱动线开路
|
|
|
95 |
P16A013
|
Main positive relay drive line open circuit fault主正继电器驱动线开路故障
|
1. The main positive relay drive line is open circuit1.主正继电器驱动线开路
|
|
|
96 |
P16A213
|
Main negative relay relay drive line open circuit fault主负继电器继电器驱动线开路故障
|
1. The main negative relay drive line is open circuit1.主负继电器驱动线开路
|
|
|
97 |
P16A313
|
DC fast charging relay drive line open circuit fault快充继电器驱动线开路故障
|
1. The DC fast charging relay drive line is open circuit1.快充继电器驱动线开路
|
|
|
98
|
P16484B
|
thermal runaway failure热失控故障
|
1. Battery thermal runaway1.电池热失控
|
|
|
99 |
P164921
|
Low insulation resistance alarm (relay closed)绝缘阻值低告警（继电器闭合）
|
1. Abnormal insulation of the high-voltage part of the vehicle1.整车高压部分绝缘异常
|
|
|
100
|
P164A21
|
Low insulation resistance alarm (relay disconnected)绝缘阻值低告警（继电器断开）
|
1. Abnormal insulation of the high-voltage part of the vehicle1.整车高压部分绝缘异常
|
|
|
101 |
P161501
|
Current sensor 1 electrical failure电流传感器1电气故障
|
1. Current sensor 1 fault1.电流传感器1故障
|
|
|
102
|
P161601
|
Current sensor 2 electrical failure电流传感器2电气故障
|
1. Current sensor 2 failure1.电流传感器2故障
|
|
|
103 |
P164262
|
VCU CAN command communication timeoutVCU CAN指令通信超时
|
1. The BMS cannot receive the information of the VCU node, and the wiring harness or VCU is faulty.1.BMS无法接收到VCU节点的信息，线束或者VCU发生了故障
|
|
|
104 |
P16E906
|
Large single voltage inconsistency单体电压不一致性大
|
1. The voltage difference between the internal cells of the battery is too large and the cells are in an unbalanced state.1.电池内部电芯电压差异过大，电芯处于不均衡状态
|
|
|
105 |
P167000
|
Functional safety requires high voltage power off功能安全请求高压下电
|
1. Functional safety related fault detected1.检测到功能安全相关故障
|
|
|
106 |
P164791
|
The battery pack temperature difference is too large电池包温差过大
|
1. The battery temperature difference exceeds the alarm value and the cooling system is abnormal.1.电池温差超出报警值，冷却系统异常
|
|
|
2. There is an abnormal temperature source near the battery pack2.电池包附近存在异常温度源
|
||||
|
107 |
P164A91
|
In the DC fast charging state, the high voltage power-down process times out when waiting for the current to drop.快充状态下高压下电过程等待电流下降超时
|
1. The charging station did not stop output in time during high-voltage power-off under DC fast charging state.1.快充状态下高压下电过程中桩没有及时停止输出
|
|
|
108 |
P164A00
|
DC fast charging station parameters do not match快充桩参数不匹配
|
1. The power of the DC fast charging station does not meet the battery demand1.快充桩功率不满足电池需求
|
|
|
109
|
P164991
|
DC fast charging and reconnection reaches the maximum number of times快充重连达到最大次数
|
1. DC fast charging station or BMS communication timeout1.快充桩或BMS通讯超时
|
|
|
110 |
P164900
|
DC fast-charging plug connection failure (CC2)快充枪连接故障(CC2)
|
1. The DC fast charging port or DC fast-charging plug is faulty1.快充口或快充枪故障
|
|
|
111
|
P169087
|
Charging station status message timeout (CCS)充电桩状态报文超时(CCS)
|
1. DC fast charging station communication message timeout1.快充桩通讯报文超时
|
|
|
112 |
P169187
|
Charger request identification message timeout (CRM == 0x00)充电机请求识别报文超时(CRM == 0x00)
|
1. DC fast charging station communication message timeout1.快充桩通讯报文超时
|
|
|
113 |
P169287
|
Charger confirmation identification message timeout (CRM==0xAA)充电机确认识别报文超时(CRM==0xAA)
|
1. DC fast charging station communication message timeout1.快充桩通讯报文超时
|
|
|
114
|
P169387
|
Output ready message timeout (CRO)输出准备就绪报文超时(CRO)
|
1. DC fast charging station communication message timeout1.快充桩通讯报文超时
|
|
|
115
|
P169487
|
Charger statistics packet timeout (CSD)充电机统计报文超时(CSD)
|
1. DC fast charging station communication message timeout1.快充桩通讯报文超时
|
|
|
116
|
P169587
|
Charger abort charging message timeout (CST)充电机中止充电报文超时(CST)
|
1. DC fast charging station communication message timeout1.快充桩通讯报文超时
|
|
|
117 |
P169687
|
Maximum output capacity message timeout (CML)最大输出能力报文超时(CML)
|
1. DC fast charging station communication message timeout1.快充桩通讯报文超时
|
|
|
118 |
U059481
|
Invalid data received from DCU接收到DCU的无效数据
|
1. The information received by the BMS from the DCU node is invalid, and the wiring harness or DCU is faulty.1.BMS接收到DCU节点的信息无效，线束或者DCU发生了故障
|
|
|
119 |
U049981
|
Invalid data received from TBOX接收到TBOX的无效数据
|
1. The information received by the BMS from the TEL node is invalid, and the wiring harness or TEL is faulty.1.BMS接收到TEL节点的信息无效，线束或者TEL发生了故障
|
|
|
120 |
U108081
|
Invalid data received from VCU接收到VCU的无效数据
|
1. The information received by the BMS from the VCU node is invalid, and the wiring harness or VCU is faulty.1.BMS接收到VCU节点的信息无效，线束或者VCU发生了故障
|
|
|
121 |
P161709
|
High voltage sampling SPI communication failure高压采样SPI通讯故障
|
1. Sensor power supply 1 failure1.传感器供电1故障
|
|
|
122 |
P167288
|
Charging CAN bus is off充电CAN总线关闭
|
1.CAN line or network failure1.CAN线或网络故障
|
|
|
123
|
P167188
|
Internal CAN bus is closed内CAN总线关闭
|
1.CAN line or network failure1.CAN线或网络故障
|
|
|
124 |
U007688
|
ECAN/CANFD2 bus closedECAN/CANFD2总线关闭
|
1.CAN line or network failure1.CAN线或网络故障
|
|
|
125 |
U108087
|
Lost communication with VCU与VCU丢失通信
|
1. The BMS cannot receive the information of the VCU node, and the wiring harness or VCU is faulty.1.BMS无法接收到VCU节点的信息，线束或者VCU发生了故障
|
|
|
126 |
U029287
|
Lost communication with DCU与DCU丢失通信
|
1. The BMS cannot receive the information of the DCU node, and the wiring harness or DCU is faulty.1.BMS无法接收到DCU节点的信息，线束或者DCU发生了故障
|
|
|
127
|
U019887
|
Lost communication with TBox与TBox丢失通信
|
1. The BMS cannot receive the information from the TEL node, and the wiring harness or TEL is faulty.1.BMS无法接收到TEL节点的信息，线束或者TEL发生了故障
|
|
|
128 |
P167941
|
Does not match VCU software version verification与VCU软件版本校验不匹配
|
1.The VCU or BMS software version is incorrect1.VCU或者BMS软件版本不正确
|
|
|
129
|
P167A41
|
Does not match DCU software version verification与DCU软件版本校验不匹配
|
1.The DCU or BMS software version is incorrect1.DCU或者BMS软件版本不正确
|
|
|
130 |
P169101
|
DC fast-charging plug connection signal (A+) failure快充充电枪连接信号（A+）故障
|
1. The A+ detection port of the BMS motherboard is damaged.1.BMS主板A+检测口损坏
|
|
|
131
|
P169011
|
DC fast-charging plug connection signal (CC2) short to ground快充充电枪连接信号（CC2）短地
|
1. The CC2 detection port of the BMS motherboard is damaged.1.BMS主板CC2检测口损坏
|
|
|
132 |
P169B02
|
AFE daisy chain communication failureAFE菊花链通信故障
|
1.AFE daisy chain communication failure1.AFE菊花链通讯故障
|
|
|
133
|
P166002
|
High voltage and current sampling chip communication error高压及电流采样芯片通讯错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
134 |
P166141
|
High voltage sampling chip calibration error高压采样芯片校验错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
135
|
P166191
|
High-voltage sampling chip parameter transmission error高压采样芯片传参数错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
136 |
P166144
|
High voltage sampling chip configuration register error高压采样芯片配置寄存器错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
137 |
P166193
|
High voltage sampling chip start request error高压采样芯片启动请求错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
138 |
P166194
|
Uncontrollable errors inside the high-voltage sampling chip高压采样芯片内部不可控错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
139
|
P166292
|
High voltage sampling chip temperature port (I/0) switching error高压采样芯片温度端口（I/0）切换错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
140
|
P166392
|
High voltage sampling chip port (I/O) configuration error高压采样芯片端口（I/O）配置错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
141 |
P166492
|
High-voltage sampling chip analog-to-digital conversion (ADC) sampling error高压采样芯片模数转换（ADC）采样错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
142
|
P166105
|
High voltage sampling chip internal diagnostic error高压采样芯片内部诊断错误
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
143 |
P166583
|
Bridge chip data checksum (CRC) error桥接芯片数据校验（CRC）错误
|
1. Bridge chip hardware failure1.桥接芯片硬件故障
|
|
|
144 |
P166594
|
Bridge chip responds with wrong address桥接芯片响应地址错误
|
1. Bridge chip hardware failure1.桥接芯片硬件故障
|
|
|
145 |
P166694
|
Bridge chip responds to frame command error桥接芯片响应帧命令错误
|
1. Bridge chip hardware failure1.桥接芯片硬件故障
|
|
|
146
|
P166602
|
Bridge chip communication (SPI) transmission error桥接芯片通讯（SPI）传输错误
|
1. Bridge chip hardware failure1.桥接芯片硬件故障
|
|
|
147
|
P166606
|
Bridge chip queue exception error桥接芯片队列异常错误
|
1. Bridge chip hardware failure1.桥接芯片硬件故障
|
|
|
148
|
P166706
|
Bridge chip execution command dequeue error桥接芯片执行命令出队列错误
|
1. Bridge chip hardware failure1.桥接芯片硬件故障
|
|
|
149 |
P166792
|
Bridge chip configuration register (MISMATCH) error桥接芯片配置寄存器（MISMATCH）错误
|
1. Bridge chip hardware failure1.桥接芯片硬件故障
|
|
|
150 |
P166906
|
Bridge chip execution task timeout error桥接芯片执行任务超时错误
|
1. Bridge chip hardware failure1.桥接芯片硬件故障
|
|
|
151 |
P166806
|
AFE chip execution command dequeuing error\verification errorAFE芯片执行命令出队列错误\校验错误
|
1.AFE chip hardware failure1.AFE芯片硬件故障
|
|
|
152
|
P166877
|
AFE chip sleep mode setting failure failureAFE芯片休眠模式设置失败故障
|
1.AFE chip hardware failure1.AFE芯片硬件故障
|
|
|
153 |
P166892
|
AFE chip configuration register (MISMATCH) error\task timeout errorAFE芯片配置寄存器（MISMATCH）错误\任务超时错误
|
1.AFE chip hardware failure1.AFE芯片硬件故障
|
|
|
154
|
P166992
|
AFE chip sleep failure errorAFE芯片休眠失败错误
|
1.AFE chip hardware failure1.AFE芯片硬件故障
|
|
|
155 |
P166A09
|
AFE temperature sensor failureAFE温度传感器故障
|
1.AFE chip hardware failure1.AFE芯片硬件故障
|
|
|
156
|
P166A02
|
Timer communication (SPI) error定时器通讯（SPI）错误
|
1. Main control chip hardware failure1.主控芯片硬件故障
|
|
|
157 |
P166A92
|
High voltage sampling chip initialization failure高压采样芯片初始化故障
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
158
|
P166205
|
High voltage sampling chip self-test failure高压采样芯片自检故障
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
159 |
P166101
|
High voltage sampling chip power supply failure高压采样芯片电源故障
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
160
|
P166192
|
High-voltage sampling chip analog-to-digital conversion failure高压采样芯片模数转换故障
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
161 |
P166196
|
High-voltage sampling chip low-pass filter failure高压采样芯片低通滤波故障
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
162
|
P166113
|
High voltage sampling chip high voltage open roadblock高压采样芯片高压开路路障
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
163 |
P166296
|
High voltage sampling chip overcurrent comparator failure高压采样芯片过流比较器故障
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
164
|
P166396
|
High-voltage sampling chip current sampling polarity fault高压采样芯片电流采样极性故障
|
1. High-voltage sampling chip hardware failure1.高压采样芯片硬件故障
|
|
|
165 |
P166109
|
AFE unit sampling failureAFE单体采样故障
|
1.AFE sampling line disconnection fault1.AFE采样线断线故障
|
|
|
166
|
P161798
|
High and low side chip communication failure高低边芯片通信故障
|
1. High and low side chip failure1.高低边芯片故障
|
|
|
167 |
P161717
|
CAN transceiver communication (SPI) failureCAN收发器通信(SPI)故障
|
1. Vehicle CAN transceiver failure1.整车CAN收发器故障
|
|
|
168
|
P161917
|
CAN transceiver initialization failureCAN收发器初始化故障
|
1. Vehicle CAN transceiver failure1.整车CAN收发器故障
|
|
|
169 |
P161911
|
Errors generated when CAN transceiver is runningCAN收发器运行时产生的错误
|
1. Vehicle CAN transceiver failure1.整车CAN收发器故障
|
|
|
170
|
P161916
|
CAN transceiver unexpected errorCAN收发器非预期错误
|
1. Vehicle CAN transceiver failure1.整车CAN收发器故障
|
|
|
171
|
P161817
|
Errors generated during operation of high- and low-side chips高低边芯片运行期间产生的错误
|
1. High and low side chip failure1.高低边芯片故障
|
|
|
172 |
P161809
|
High and low side chip initialization error高低边芯片初始化错误
|
1. High and low side chip failure1.高低边芯片故障
|
|
|
173
|
P161898
|
Unexpected errors in high and low side chips高低边芯片非预期错误
|
1. High and low side chip failure1.高低边芯片故障
|
|
|
174
|
P161816
|
Power chip initialization failure电源芯片初始化故障
|
1. Power management chip failure1.电源管理芯片故障
|
|
|
175 |
P161909
|
Power chip hardware failure电源芯片硬件故障
|
1. Power management chip failure1.电源管理芯片故障
|
|
|
176
|
P161998
|
Power chip status unexpected failure电源芯片状态非预期故障
|
1. Power management chip failure1.电源管理芯片故障
|
|
|
177
|
P169402
|
Power management chip SPI communication error电源管理芯片SPI通信错误
|
1. Power management chip failure1.电源管理芯片故障
|
|
|
178 |
P166442
|
OS failureOS故障
|
1. General programming faults1.一般编程故障
|
|
|
179 |
P166B09
|
Extreme overcurrent fault极限过流故障
|
1. There is a short circuit or abuse on or outside the battery pack.1.电池包外部或者外部存在短路或者滥用情况
|
|
|
180 |
P166C09
|
Abnormal shunt temperature alarm分流器温度异常告警
|
1. Loose connection of copper bars, abnormal shunt, abnormal sampling harness, and abnormal BMS main board1.铜排虚接、分流器异常、 采样线束异常、BMS主板异常
|
|
|
181 |
P166D09
|
Abnormal alarm of shunt current sampling value分流器电流采样值异常告警
|
1. Loose connection of copper bars, abnormal shunt, abnormal sampling harness, and abnormal BMS main board1.铜排虚接、分流器异常、 采样线束异常、BMS主板异常
|
|
|
182 |
P16A572
|
DC fast charging relay cannot close快充继电器无法闭合
|
1. Abnormal charging station1.充电桩异常
|
|
|
183 |
P169094
|
Charging station sends BCL message to suspend charging for too long充电桩发送BCL报文暂停充电过长
|
1. Abnormal charging station1.充电桩异常
|
|
|
184 |
P164033
|
Charging current is too low for a long time充电电流长时间过低
|
1. Abnormal charging station1.充电桩异常
|
|
|
185 |
P165094
|
DC fast charging unexpectedly stops (the charging station sends a charger error message [CEM message])快充意外停止故障（充电桩发出充电机错误报文[CEM报文]）
|
1. Abnormal charging station1.充电桩异常
|
|
|
186 |
P165194
|
DC fast charging unexpectedly stops (the charging station sends a stop message [CST]: the charging station setting conditions are met)快充意外停止故障（充电桩发出中止报文[CST]:达到桩设置条件）
|
1. Abnormal charging station1.充电桩异常
|
|
|
187 |
P165294
|
DC fast charging unexpectedly stops (the charging station sends a stop message [CST:] to stop manually)快充意外停止故障（充电桩发出中止报文[CST:]人工停止）
|
1. Abnormal charging station1.充电桩异常
|
|
|
188 |
P165394
|
DC fast charging stops unexpectedly (Charging station sends abort message [CST]: Charging station fails)快充意外停止故障（充电桩发出中止报文[CST]:充电桩故障）
|
1. Stop charging due to manual operation1.人为操作停止充电
|
|
|
189 |
P165494
|
DC fast charging unexpected stop failure (charging station sends abort message [CST]: BMS active stop failure)快充意外停止故障（充电桩发出中止报文[CST]:BMS主动停止故障）
|
1. Abnormal charging station1.充电桩异常
|
|
|
190 |
P16AA72
|
DC fast charging negative relay cannot close快充负继电器无法闭合
|
1. Main negative relay failure1.主负继电器故障
|
|
|
191 |
P16AA73
|
DC fast charging negative relay sticking快充负继电器粘连
|
1. Main negative relay failure1.主负继电器故障
|
|
|
192 |
P167B41
|
Does not match IPS software version verification与IPS软件版本校验不匹配
|
1. The IPS or BMS software version is incorrect1.IPS或者BMS软件版本不正确
|
|
|
193 |
U011287
|
Lost communication with IPS与IPS丢失通信
|
1. The BMS loses the information of the IPS node, and the wiring harness or IPS fails.1.BMS丢失IPS节点的信息，线束或者IPS发生了故障
|
|
|
194 |
U041381
|
Invalid data received from IPS接收到IPS的无效数据
|
1. The information received by the BMS from the IPS node is invalid, and the wiring harness or IPS is faulty.1.BMS接收到IPS节点的信息无效，线束或者IPS发生了故障
|
|
|
195 |
P162109
|
Pressure sensor hardware failure压力传感器硬件故障
|
1. Pressure sensor failure1.压力传感器故障
|
|
|
196 |
P162209
|
Delayoff circuit hardware failureDelayoff电路硬件故障
|
1. Abnormal reset holding circuit failure1.异常复位保持电路故障
|