Maintenance operations › Maintenance › Overview
定期保养 · T00609617

 Regular maintenance定期保养

If necessary, after inspection, follow the steps of adding, cleaning, cleaning, adjusting, lubricating, repairing or replacing.如果需要，经检查后，按添加、清洁、清洗、调整、润滑、维修或更换的步骤进行。
Maintenance items保养项目
Maintenance cycle保养周期
Remarks备注
Check the condition of cooling system pipes and connections.检查冷却系统管路及连接部位的状态。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the cooling system for leaks and replenish coolant if necessary.检查冷却系统是否泄漏，必要时补充冷却液。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the integrated electric drive assembly mounting bracket, check the mounting bolts of the bracket, and reinforce any looseness.检查集成电力驱动总成安装支架，检查支架安装螺栓，并对松动现象进行加固。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
High-voltage wire harness: 1. Check whether there is looseness between the high-voltage wire harness cable and the connector; 2. Check whether the protection of the wire sheath of the high-voltage wire harness hole is intact and whether the wire harness is worn.高压线束：1.检查高压线束电缆与接插件之间是否松动；2.检查高压线束过线孔过线护套保护是否完好、线束是否出现磨损。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the appearance of high-voltage connectors and low-voltage connectors and whether they are installed reliably. Check whether there is any damage on the surface of the connectors and whether they are installed in place.检查高压接插件、低压接插件外观，以及是否可靠安装，检查接插件表面是否有损坏，以及是否安装到位。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Bolt inspection: Check whether the fastening bolts of the integrated electric drive assembly are loose.螺栓巡检：检查集成电力驱动总成各紧固螺栓是否存在松动。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check whether the components, fasteners, wiring harnesses, and pipelines of the integrated electric drive assembly are reliable and effective, and whether there is any interference. Check whether there is oil leakage, water leakage, etc. at the bottom of the integrated electric drive assembly.检查集成电力驱动总成各部件、紧固件、各线束、管路固定是否可靠有效，是否存在干涉现象，检查集成电力驱动总成底部是否有漏油、漏水等现象。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
★Replace coolant.更换冷却液。
Every 40,000 kilometers or 24 months每40,000公里或24个月
  
Check the reliability of the integrated electric drive assembly (check whether the high-voltage wiring harness is securely connected, check whether the fixing bracket is loose, and read the fault code).检查集成电力驱动总成的可靠情况(检查高压线束的连接是否牢靠，检查固定支架是否松动，读取故障代码)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the reliability of the high-voltage battery (check whether the high-voltage wiring harness connected to the battery box is secure, use special tools to detect the working status of the battery core, read the fault code, check whether the high-voltage battery shell is extruded, deformed, bumped, etc., check the torque of the high-voltage battery tightening bolts, and check whether the explosion-proof valve on the rear side of the high-voltage battery system has fallen off).检查动力电池的可靠情况(检查与电池箱相连接的高压线束是否牢靠，用专用工具检测电芯工作状态，读取故障代码，检查动力电池壳体是否有挤压、变形、磕碰等，检查动力电池紧固螺栓力矩，检查动力电池系统后侧防爆阀是否脱落)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the reliability of the integrated power system (check whether the high-voltage and low-voltage connector connections are intact, check whether the positive and negative wiring harness connections of the low-voltage 12V battery are firm, check whether the mounting bolts are firm, and read the fault code).检查集成电源系统的可靠情况(检查高压和低压接插件连接是否完好，检查低压12V蓄电池正负极线束连接是否牢固，检查安装螺栓是否牢靠，读取故障代码)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the high-voltage wire harness in special parts (whether the high-voltage wire harness and the high-voltage wire harness guard plate under the chassis are damaged, and whether the connection part with the motor is firm and intact).检查特殊部位的高压线束(底盘下的高压线束及高压线束护板是否有损坏，与电机连接部位是否牢靠、完好)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
★Replace brake fluid.更换制动液。
Every 40,000 kilometers or 24 months每40,000公里或24个月
  
★Replace differential reducer gear oil.更换差速减速器齿轮油。
Every 60,000 kilometers or 36 months每60,000公里或36个月
  
Check the parking brake and brake pedal (check the function and free travel of the pedal and parking brake).检查驻车制动器、制动踏板(检查踏板和驻车制动的功能、自由行程)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the brake disc and brake friction pad (check thickness and wear, replace if necessary).检查制动盘及制动摩擦片(检查厚度及磨损情况，必要时更换)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the wheel fixing bolts (check and tighten according to the specified torque).检查车轮固定螺栓(按规定扭矩检查并紧固)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the wear of tires/wheels/spare tires (if equipped), rotate the tires if necessary, and correct the tire pressure at the same time.检查轮胎/轮毂/备用轮胎(如有配置)磨损情况，必要时进行轮胎换位，同时矫正轮胎气压。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the chassis bolts (check and tighten according to the specified torque).检查底盘螺栓(按规定扭矩检查并紧固)。
Every 10,000 kilometers or 12 months每10,000公里或12个月
  
Check the brake system (check the brake fluid pipeline for leaks, check the brake fluid level, and refill if necessary).检查制动系统(检查制动液管路是否泄漏，检查制动液液面，必要时补充)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the steering tie rod (check the gap and whether the connection is firm), and check the bolts at the connection between the steering column and the steering gear (check and tighten according to the specified torque).检查转向横拉杆(检查间隙，连接是否牢固)，检查转向管柱与转向器连接处螺栓(按规定扭矩检查并紧固)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the reliability of the differential reducer (whether the oil seal is leaking and whether the casing is damaged).检查差速减速器的可靠情况(油封是否漏油，壳体是否磕伤)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the reliability of the brake pipeline (whether there is leakage and whether the protective layer is damaged).检查制动管路的可靠情况(有无泄漏，保护层是否损坏)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the bottom of the car body (check whether the brake fluid pipe and bottom protective layer are damaged).检查车身底部(检查制动液管及底部保护层是否损坏)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the suspension ball joint and dust cover (the ball head is not loose and the dust cover is not leaking).检查悬架球节和防尘罩(球头无松动，防尘罩有无漏油)。
Every 10,000 kilometers or 12 months每10,000公里或12个月
  
Check the suspension components (check whether the bushings are aged or damaged, whether the connecting bolts and nuts are torqued, and whether the rods are deformed or cracked).检查悬架组件(检查衬套有无老化、破损，连接螺栓、螺母扭矩，杆件有无变形、裂纹)。
Every 10,000 kilometers or 12 months每10,000公里或12个月
  
Check the wiper/cleaning device (wiper blade cleanliness, replace the wiper blade if necessary, add washing fluid, check function, adjust the nozzle if necessary).检查雨刮器/清洗装置(刮片刮净度，必要时更换刮片，加注洗涤液，检查功能，必要时调整喷嘴)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the sealing ring of the wiper shaft of the front wiper and apply lubricating oil (after removing the sealing ring, apply lubricating oil to the position that matches the wiper shaft. The grease should be lithium-based grease, and its performance needs to be resistant to -40°C low temperature).检查前刮水器刮轴密封圈密封性并涂润滑油(需将密封圈拆下后，将润滑油涂覆在与雨刮轴配合的位置，油脂应为锂基脂，性能需耐-40℃低温)。
Every 10,000 kilometers or 6 months每10,000公里或6个月
  
Clean the front windshield gutter drain hole.清洁前风窗玻璃落水槽排水孔。
Every 10,000 kilometers or 6 months每10,000公里或6个月
  
Check the door stopper, fixing pin, door lock, hood lock, trunk lock, latch, front hatch/rear door hinge (check and tighten according to the specified torque; the door stopper needs to be cleaned of dust and lubricated with SYN-TECHNS-12290-GB; the door lock ratchet and the mating surface of the latch should be cleaned of dust and lubricated with WD_40).检查车门限位器、固定销、门锁、发动机罩锁、行李箱锁、锁扣、前舱盖/后背门铰链(按规定扭矩检查并紧固；车门限位器需清理灰尘并涂SYN-TECHNS-12290-GB润滑；门锁棘轮及锁扣匹配面清理灰尘并涂WD_40润滑)。
Every 10,000 kilometers or 6 months每10,000公里或6个月
  
The electric tailgate drive rod/balance rod/gas spring ball socket is filled with grease for lubrication (without disassembling the two rods). Grease requirements: lithium soap-based synthetic hydrocarbon, high viscosity, operating temperature: -30°C~120°C.电动后背门驱动杆/平衡杆/气弹簧球窝加注油脂进行润滑(在不拆卸两杆的情况下)，油脂要求：锂皂基合成烃，高粘度，使用温度：-30℃~120℃。
Every 10,000 kilometers or 6 months每10,000公里或6个月
  
Check the lighting appliances and electrical equipment inside and outside the car body.检查车身内外照明电器、用电设备。
Every 5,000 kilometers or 3 months每5,000公里或3个月
  
Self-diagnosis (use special diagnostic equipment to query fault information).自诊断(用专用诊断设备查询故障信息)。
Every 10,000 kilometers or 6 months每10,000公里或6个月
  
Check the 12V battery (use special tools to check the condition of the 12V battery, whether the positive and negative poles are firmly connected, and check the voltage).检查蓄电池(用专用工具检查蓄电池状况，正负极连接是否牢固，检测电压)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
First-service item首保项目
Check the front and rear combination lights (check lights and adjust if necessary).检查前、后组合灯(检查灯光，必要时调整)。
Every 10,000 kilometers or 6 months每10,000公里或6个月
  
Check the cabin air filter element.检查空调滤清器滤芯。
Every 10,000 kilometers or 6 months每10,000公里或6个月
  
★Replace the cabin air filter element.更换空调滤清器滤芯。
Every 10,000 kilometers or 12 months每10,000公里或12个月
  
Test run (performance check).试车(性能检查)。
Carry out after each maintenance每次保养后进行
  
Visually inspect the following items目视检查下列项目
Drive shaft sheath (whether there is grease leakage or damage).驱动轴护套(有无油脂渗漏或损坏)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
  
Differential reducer and high-voltage wiring harness (whether there are signs of dynamic collision).差速减速器与高压线束(有无动态磕碰痕迹)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
  
High-voltage wire harness sheath under the floor (whether there are any knock marks).地板下高压线束护套(有无磕碰痕迹)。
Initial 5,000 kilometers or 6 months, subsequent intervals of 10,000 kilometers or 12 months首次5,000公里或6个月，后续每隔10,000公里或12个月
  
Note 1:注1：
The meaning of the symbols used in the table:表中所用符号含义：
"I": Inspect and adjust or replace if necessary.“I”：检视，如需要应进行调整或更换。
“★": Replace.”：更换。
Note 2:注2：
The contents in the above table are based on normal driving conditions. If the car is used under one or more severe conditions, please follow the supplementary maintenance instructions for maintenance.上表内容是根据正常行驶条件制定的，若在一种或多种恶劣条件下使用汽车，请按补充保养说明进行保养。